Product ID:CAT FOR 463-6-3 OR 463-6-5, X 306
MSDS Date:08/18/1989
FSC:8030
NIIN:00N014239
MSDS Number: BKKWG

AKZO COATINGS INC

434 WEST MEATS AVENUE
ORANGE, CA 92665
US

Emergency Phone: 313-589-3660; 313-855-7313

Info Phone: 513-433-4996

Cage: 98502

AKZO COATINGS INC

ORANGE, CA 92661 US

Telephone: 714-637-1750; CHEMTREC 800-424-9300

Cage: 98502

OVEREXP MAY CAUSE RED BLOOD CELL AND LEUCOCYTE

RTECS: 9999999ZZ

ISOPROPYL ALCOHOL (SARA III)

CAS: 67-63-0

RTECS: NT8050000

Fraction By Weight: 40-55%

OSHA PEL 400 PPM/500 STEL

ACGIH TLV: 400 PPM/500STEL;9192

XYLENES (O-,M-,P- ISOMERS) (SARA III)

CAS: 1330-20-7

RTECS: ZE2100000

Fraction By Weight: 40-55%

OSHA PEL 100 PPM/150 STEL

ACGIH TLV: 100 PPM/150STEL;9192

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

DO NOT WELD OR FLAME CUT AN EMPTY DRUM. DO NOT

RTECS: 9999999ZZ

KIDNEY DMG. OVEREXP TO MATL HAS BEEN SUGGESTED

RTECS: 9999999ZZ

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYE IRRITANT, CNTCT MAY CAUSE
EYE BURNS OR CORNEAL INJURY. EXCESS INHAL OF VAPS CAN CAUSE NASAL &
RESP IRRIT, DIZZ, WEAK, FATG, NAUS, HDCH, POSS UNCON, & EVEN
ASPHYXIATION. PRLNG CNTCT W/SKIN M AY LEAD TO EXTRACTION OF NATURAL
OILS W/RESULTANT MILD IRRIT. INGEST CAN CAUSE GI IRRIT, NAUS, (SEE
EFTS OF OVEREXP)
Explanation of Carcinogenicity:XYLENE: GROUP 3.
Effects of Overexposure:HLTH HAZ: VOMIT, & DIARR. EYE CNTCT MAY CAUSE
SEV IRRIT, REDNESS, TEARING, BLURRED VISION, & A SENSATION OF
SEEING HALOS AROUND LIGHTS. ASPIR OF MATL INTO LUNGS CAN CAUSE CHEM
PNEUMIT WHICH CAN BE FAT AL. INTENTIONAL MISUSE BY DELIB CONC/INHAL
CONTENTS MAY BE HARMFUL/FATAL. RPTS HAVE ASSOC RPTD/PRLNG (SEE SUPP
DATA)
Medical Cond Aggravated by Exposure:NONE EXPECTED.

First Aid:INHAL: REMOVE TO FRESH AIR. GIVE ARTIFICIAL RESPIRATION IF
NECESSARY. SKIN: WASH WITH SOAP AND WATER. EYES: FLUSH WITH WATER
FOR AT LEAST 15 MINUTES, CONSULT MD. INGEST: DRINK ONE OR TWO
GLASSES OF WA TER TO DILUTE. DO NOT INDUCE VOMITING. CONSULT MD OR
POISON CONTROL CENTER IMMEDIATELY. TREAT SYMPTOMATICALLY.

Flash Point Method:TCC
Flash Point:53.0F,11.7C
Lower Limits:1.0
Extinguishing Media:FOAM, CO*2, DRY CHEMICALS
Fire Fighting Procedures:WATER MAY BE INEFTIVE. WATER SHOULD BE USED TO
COOL CNTNRS EXPOSED TO FIRE. FIRE FIGHTING PERSONNEL SHOULD WEAR
NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP .
Unusual Fire/Explosion Hazard:KEEP CNTNRS TIGHTLY CLOSED. ISOLATE FROM
HEAT, SPARKS, ELEC EQUIP, OPEN FLAME. CLOSED CNTNRS MAY EXPLODE
WHEN EXPOSED TO EXTREME HEAT, APPLICATN (SEE SUPP DATA)

Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. AVOID
BREATHING VAPORS. VENTILATE AREA. REMOVE WITH INERT ABSORBENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:STORE CONTAINERS OUT OF SUN & AWAY
FROM HEAT, SPARKS, OPEN FLAMES. CLOSE CONTAINERS AFTER EACH USE.
CONSULT NFPA CODE FOR ADDNL STORAGE REQUIREMENTS.
Other Precautions:DO NOT TAKE INTERNALLY. USE APPRVD BONDING &
GROUNDING PROC. OBSERVE LABEL PREC. KEEP CLOSURES TIGHT & CNTNR
UPRIGHT TO PREVENT LEAKAGE. NEVER USE PRESS TO EMPTY--DRUM IS NOT A
PRESSURE VESSEL. AVOID BREATHING SANDING DUST. (SEE INGRED 03)

Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR DEVICE. IN
CONFINED AREAS USE NIOSH/MSHA APPROVED AIRLINE RESPIRATOR OR HOOD.
Ventilation:SUFFICIENT VENTILATION TO KEEP VAP CONC BELOW GIVEN
TLV/LEL. FOR BAKING FINISHES, EXHAUST VAPS EMITTED ON HEATING.
Protective Gloves:IMPERVIOUS GLOVES
Eye Protection:CHEMICAL WORKERS GOGGLES
Other Protective Equipment:EYE BATH AND SHOWER, CHEMICAL RESISTANT
APRON, BOOTS OR OTHER CLOTHING IF NEEDED TO AVOID RPTD/FREQ SKIN
CONTACT.
Work Hygienic Practices:WASH HANDS BEFORE EATING, SMOKING OR USING
WASHROOM.
Supplemental Safety and Health
EXPLO HAZ: TO HOT SURFS REQ SPEC PREC. DURING EMER CNDTNS OVEREXP TO
DECOMP PRODS MAY CAUSE HLTH HAZ. SYMPS MAY NOT BE IMMED APPARENT.
GET MD. EFTS OF OVEREXP: OCCUP OVEREXP TO SOLVS W/PERM BRAIN & NE
RV SYS DMG. CHRONIC: RPTD OVEREXP MAY RSLT IN DELAYED KIDNEY
INJURY. CHRONIC EXPOS MAY CAUSE LIVER AND (SEE INGRED 04)

HCC:F3
Boiling Pt:B.P. Text:180F,82C
Vapor Pres:SEE INGRED
Vapor Density:> AIR
Spec Gravity:0.839
Evaporation Rate & Reference:SLOWER THAN ETHER
Percent Volatiles by Volume:90.6

Stability Indicator/Materials to Avoid:YES
NONE REASONABLY FORESEEABLE
Hazardous Decomposition Products:CO, CO*2, SMOKE, NO*X

Waste Disposal Methods:INCINERATE IN AN APPROVED FACILITY. DO NOT
INCINERATE CLOSED CNTNRS. DISPOSE OF I/A/W FEDERAL, STATE AND LOCAL
POLLUTION CONTROL REQUIREMENTS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.